Question
Asked 25th Jan, 2016

How to calculate precharging resistors and precharging time for input DC link capacitors and Output AC filter capacitors of an Inverter?

Hello,
I am searching some concrete document on how to calculate the precharging resistor installed in inverter which is used for precharging of DC link and AC filter capacitors of 3-phase grid tied inverter. They are essential to limit the inrush currents for the capacitors when inverter is switchied on.

Most recent answer

Aalok Bhatt
Renesas Electronics
Hello Deepak, can u share the source of this document ? Would like to understand the problem to correlate more.

All Answers (12)

Bhupendra Desai
Indian Institute of Technology Roorkee
T=1/RC,
Miao-xin Wang
Schneider Electric
Yes. If you can afford to charge very slowly, take a big ressistor value. Then you can have low inrush current, and be able to use low power resistor, as the peak power will be E^2/R.  (E is the input DC source voltage).
In case you need to charge quickly, then take R=E/Imax, Imax is the maximal inrush current that the input DC source can support.  Again the resistor should support a peak power of E^2/R. You will see this value could be quite high. In practice, you can use one with a little bit smaller power rating.  
1 Recommendation
Aalok Bhatt
Renesas Electronics
Thank you Mr. Wang. This makes sense.
Just to clarify you, I am pre-charging the inverter DC link via grid before starting PWM and therefore the Grid power goes in to B-6 Rectifier (Formed via FWD of IGBTs) and then it charges the DC link.
In this case, from my view, the limitation comes via Capacitor RMS current withstand capability i.e, Imax. Thus, if I want to calculate resistor and power then,
Take R=Vm/Imax where Vm is maximum grid voltage i.e. 1.4142*Vrms and Imax = Maximum capacitor RMS current withstand capability
After that power rating can be selected as,
Peak power = (Vm^2)/R. Where Vm is peak voltage of the AC grid.
Is my concept is correct? Please verify this method. I will be grateful and obliged.:)
Thanks and Regards
Aalok
Miao-xin Wang
Schneider Electric
Yes. Your approach looks correct to me.
I guess you verifyed that Imax of your capacitor is less that Imax of your input diodes.
In case you want to charge even faster, have in mind that the capacitor could support an inrush current larger than Maximum capacitor RMS current withstand capability.
1 Recommendation
Aalok Bhatt
Renesas Electronics
yes you are right again Mr. Wang. The specified maximum capacitor RMS current is a continuous rating. However, the larger current withstanding capability will merely compromise on the service life of my inverter which is not desirable. Therefore, I consider maximum capacitor RMS current as upper limit.
I also varified that my diode is having much larger current withstand capability as I am working on MW range inverter.
After the calculation, I will again post here to crosscheck with estimated precharging time as per 1/RC to close the question loop.
Guido Botto
Ansaldo Energia
1) choose precharge time as you like (I suggest 1-3 sec) and calculate resistor value keeping in mind that it takes 3 time constant to fully charge the capacitors. 
2) To size resistor wattage calculate the energy absorbed by the resistor (1/4 Cv2). Don't mind peak power but consider peak voltage and energy: these are the two parameters you have to match in the resistor data sheet.
There are resistors that are specifically made for precharge circuits. Best of all are high voltage ceramic carbon resistor from HVR as they are compact and can sustain high energy and high voltage. Second choice are wirewound resistors; don't use thick film, thet cannot sustain high energy pulse 
2 Recommendations
Aalok Bhatt
Renesas Electronics
HEllo Guid,
Thank you for your insightful answer.. I got your point.
Beladel Abdelkader
Ziane Achour University of Djelfa
E^2/R  and  R=E/Im
1 Recommendation
Aalok Bhatt
Renesas Electronics
Hello Guid,
Just one doubt. For capacitor energy, it will be 1/2C*(V^2). For 560 V AC input via bridge rectifier, it will be 560*sqrt(2) and it gives me energy of 3.3 kJ. This will be maximum energy in capacitor possible. So, Do I have to choose this much energy handling capacitor?
Can anyone suggest me the method  to calculate Precharge Resistor for a 48V Battery with Pure Resistive load.
Deepak Verma
Indian Institute of Technology Kharagpur
please find the image
2 Recommendations
Aalok Bhatt
Renesas Electronics
Hello Deepak, can u share the source of this document ? Would like to understand the problem to correlate more.

Similar questions and discussions

Related Publications

Article
The circuit modeling and analysis of resonant inverters is complex because the state variables such as inductor currents and capacitor voltages are AC dominant. The phasor dynamic modeling method maps the periodical time-varying state variables into stationary frame for each harmonic of interest. Correspondingly, the circuit is decomposed into two...
Article
The fault current of DC line rises rapidly because of the discharge of capacitor after the occurrence of fault in DC distribution network based on voltage source converters (VSC). The fragile electronic devices in the inverter require the DC breaker operate faster than the traditional AC breaker. With regard to the application of fault current limi...
Article
Wireless electric power distribution is an attractive means of supplying power to mobile equipment such as mobile phones and electric vehicles. Magnetic field coupling is the most popular method for wireless power distribution. However, this method has certain disadvantages such as power decrease in the case of inexact placement of couplings. Wirel...
Got a technical question?
Get high-quality answers from experts.